SL-FL67 Wire and Cable Heat Release Test Device
DIN EN 50399：2017 Wire and Cable Heat Release Test Device with Stainless Steel Two-Way Speed Probe
Product joriy Sim va kabel issiqlik Release Test Device
UZ 50399 bildiradi apparati va vertikal olov tarqalishi, issiqlik ozod va belgilangan sharoitlarda elektr yoki optik vertikal-ulangan odaklaştırılıp simlar yoki kabellar, tutuni ishlab chiqarish baholash uchun sinov usullari. UZ 50399 apparat va vositalarini tartibga solish va kalibrlash olov sinov paytida issiqlik ozod va tutun chiqarishni o'lchash uchun o'rnatilgan bo'lishi tafsiloti. Test protseduralar Euroclasses B1ca, B2ca, CCA va DCA yilda kabel tasniflash uchun turi tasdiqlash sinovlari uchun foydalanish uchun beriladi.
Ning Mahsulot parametrlarni Sim va kabel issiqlik Release Test Device
1. Test chamber has the dimension of 1,000±100(W) x 2,000±100(D) x 4,000±100(H) mm. The bottom surface of the test chamber is higher than the ground while the rear side is supplemented with insulated material to insulate it from heat.
2. At the lower section of the test chamber, there is a 800±20(W) x 400±10(D) sized hole at the 150±10mm position from the front side of the chamber to supply the air.
3. There is a 300±30(W)x1,000±100(D) sized exhaust hole at the rear corner of the top section of the test chamber to allow emission of the smoke during the test.
4. A flame trap is installed at the front side of the burner of the vertical flame spread tester to prevent backfire by propane to ensure the utmost safety.
5. Unlike the conventional IEC60332-3 equipment, the vertical flame spread tester records all control and test conditions with the computer to add user friendliness.
6. If stop the excessive combustion test due to Water Spray device installed for extinguish.
7. The program on the requirement on standard and 70,000Btu/h can be program.
8. Wide stainless steel ladder dimensions: 500(W) ×3, 500(H) mm.
9. Standard stainless steel ladder dimensions: 800(W) ×3, 500(H).
10. Two sets of standard propane burner and venturi mixtures.
11. Follow the standard category can program for select a test.
12. Exhaust system consists of smoke collection hood,exhaust duct, air inlet system, Centrifugal fan and frequency converter.
13. The duct section houses all gas sampling probes, temperature and mass flow probes and has ports for the smoke measuring system.
14. Paramagnetic oxygen analyzer, using the method of paramagnetic change to measure the concentration of oxygen in the gas. Concentration range of 0-25%.
15. Carbon Dioxide Analyser (infrared) for use in heat release measurement. Concentration range of 0-10%.
16. Soot filter, cold trap, drying column, pump and waste regulators for conditioning the sample gases prior to analysis.
17. Dataacquisition system and software.
Mahsulot xususiyati va Application Sim va kabel issiqlik Release Test Device
1. Standart paramagnit O2, non-dispers infraqizil CO2 gaz analizator, shu jumladan, 19 kabinet birligi;
2. Tayvan Advantech ma'lumotlar olish taxta 1 majmui, etc harorati, gaz bosimi farqi va gaz analizator ma'lumotlarni, to'plashi mumkin .;
Bunday micro differensial bosim sensori sifatida shamol bosim ochish asboblar majmui bilan 3. zanglamaydigan po'lat ikki tomonlama tezligi tekshirish;
Oyoq gaz harorati 1 majmuini aniqlash 4. The United States OMEGA K-turi termokupl 3;
PTFE quvur bilan bog'liq gaz yig'ish tekshirish qurilma majmui bilan jihozlangan 5. o'yuvchi gaz to'plash mumkin;
6. namlik olish sovuq tuzoq, zanglamaydigan po'lat quvur va PTFE shlang ulanish bilan jihozlangan gaz barqaror oqimi va kuchlanish regulyatori, Amerika CAST gaz yig'ish nasos qurilmaning 1 majmui;
7. An incandescent lamp smoke density measuring system comprising an incandescent light source and a silicon photodiode receiving device;
8. 5 neytral filtrlar, 0.1-2 optik zichligi qator bilan jihozlangan;
9. 4 import ommaviy oqim kontrolörü qurilmalar va hokazo bosim kamaytirish vana, Solenoid Vana bilan jihozlangan .;
Kalibrlash tartib, shu jumladan, va monomer yonish sinov uchun foydalanish mumkin 10. Standart test dasturi;
11. kompyuter va printer qurilmalar 1 majmui bilan jihozlangan;
Bunday chiqarish quvur va markazdan qochma fan kabi 12. Test uskunalar;
13. Ikki propan massa oqim nazorat qilish;
14. Ikki havo massa oqim nazorat qilish;
15. 22.5KW va 30KW olov kalibrlash bitta yakıcıda vazifasini bajaruvchi bir massa oqim tekshiruvi orqali amalga oshirilishi mumkin;
16. To'plam sim va kabel yonib sinov qurilma.
Application: test tizimi qutida kabel yoki tolali optik kabel modellashtirish bir o'rta olov test hisoblanadi. Test kabel vertikal standart temir narvon o'rnatilgan va kabeli yonish xulq va yonish faoliyatini baholash uchun belgilangan kontaktni manbai, xoh. Kabel olov erta bosqichlarida uchun yonish ro'yxatdan ishlash,
issiqlik relizlar stavkasining test kabel va qo'shni maydonda yong'in manbai salohiyati ta'siri bo'ylab yoyilib olov xavfli aks ettiradi. tutun zichligi sinov ko'rsatuvlari yong'in maydoni ko'rinishi va shaxsiy xavfsizligiga tutun xavf.
Mahsulot ma'lumotlarni Sim va kabel issiqlik Release Test Device
UZ 50399 Test apparat IEC 60332-3 apparati, issiqlik relizlar o'lchash, tutun zichligi o'lchov va o'zgartirish, havo kirish tizimi iborat bo'ladi. Bu qurilmani chiqarish tizimiga kanal va tegishli gaz tahlil vositalari va dasturiy ta'minot bilan, bu bilan bir kichik enstrümante bo'limiga uydirma bilan amalga oshiriladi. Yo'l Uylar datchiklari, harorat va ommaviy oqimi datchiklari va tutun o'lchash tizimi uchun portlar mavjud masal barcha gaz.
Test ma'lum yonish sharoitida kabeli yoki kabel quyidagi xususiyatlarga olishingiz mumkin:
Flame tarqalishi Flame tarqalishi FS
issiqlik reliz darajasi issiqlik reliz Rate HRR
Jami issiqlik relizlar Foydalanuvchi bilan issiqlik reliz THR
Smoke ishlab chiqarish darajasi Smoke ishlab chiqarish darajasi SPR
Jami tutun chiqarish Jami ishlab chiqarish OXSni, tutun
o'sish darajasi indeksi do'zaxdir o'sish darajasi FIGRA Burning
|
standartlari |
dIN: DIN EN 50399: 2017; UZ: EN 50399; GB/T 31248: 2014 |
|
o'lchash |
1120 mm (W) x 2200 mm (D) x 5600 mm (H) |
|
vazn |
1200kg |
|
elektr |
110V AC 60Hz / 230V AC 50Hz, 5A |
|
atrof-muhit harorati |
35 10 ° S Mehnat ° C |
|
Gas |
air and propane |
